2001 Volvo S60 Recalls

Description

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.

Consequence

A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.

Remedy

DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.

Manufacturer

VOLVO CARS OF N.A. LLC. 141

Description

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Consequence

LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Manufacturer

CARDONE INDUSTRIES, INC.

Description

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

Consequence

THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.

Remedy

DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Manufacturer

VOLVO CARS OF N.A. LLC. R155

Description

ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA, DUE TO THE COMBINATION OF FUEL QUALITY AND CLIMATE CONDITIONS, THE FUEL PUMP MAY, IN CERTAIN CASES, EXPERIENCE A REDUCED FUNCTIONALITY. THE MOST COMMON SYMPTOMS WOULD BE FUEL ODOR.

Consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy

DEALERS WILL REPLACE THE FUEL PUMP FREE OF CHARGE. THE RECALL BEGAN ON JULY 10, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Manufacturer

VOLVO CARS OF N.A. LLC. 176

Description

CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.

Consequence

THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy

OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.

Manufacturer

VOLVO CARS OF N.A. LLC. 124

Description

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Consequence

AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy

VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

Manufacturer

VOLVO CARS OF N.A. LLC. R231